多金属矿尾矿库溢流水深度处理并回用于萤石浮选试验

现代矿业 ›› 2023, Vol. 39 ›› Issue (04): 110-.

多金属矿尾矿库溢流水深度处理并回用于萤石浮选试验

薛珂¹ 李文风¹周瑜林¹ 缪亚兵¹ 陈文胜²

1. 长沙矿冶研究院有限责任公司；2. 湖南有色郴州氟化学有限公司

出版日期:2023-04-25 发布日期:2023-05-25
基金资助:
*国家自然科学基金项目（编号：51604040）。

Test on Advanced Treatment of Overflow Water from Polymetallic Tailing Pond and Its Reuse in Fluorite Flotation

XUE Ke¹ LI Wenfeng¹ ZHOU Yulin¹ MIAO Yabing¹ CHEN Wensheng²

1. Changsha Research Institute of Mining and Metallurgy Co.，Ltd.; 2. Hunan Nonferrous Chenzhou Fluorine Chemical Co.，Ltd.

Online:2023-04-25 Published:2023-05-25

摘要/Abstract

摘要： 为解决湖南某多金属矿选矿厂尾矿库溢流水难以资源化利用，造成环境污染和水资源浪费问题，进行了废水处理后回用于现场浮钨尾矿（CaF2含量为20%～22%）浮选萤石可行性研究。结果表明，高碱度、高COD废水采用次氯酸钠氧化、电氧化、活性炭吸附和芬顿氧化工艺处理，均能有效降低废水的COD，且电氧化、活性炭吸附和芬顿氧化工艺可降低废水的浊度；与废水直接回用于萤石浮选相比，各工艺处理后的废水的浮选效果不同程度改善，以活性炭吸附工艺效果最好，其精矿指标与实验室清水选矿指标接近，精矿CaF₂品位为95.63%、回收率为43.16%。因此，现场多金属选矿废水采用活性炭吸附工艺处理后可回用于萤石浮选。

关键词: 选矿废水, 深度处理, 废水回用, 萤石浮选

Abstract: In order to solve the problem of environmental pollution and water resource waste caused by the difficult in utilization of the overflow water from polymetallic tailings pond in Hunan Province，a feasibil⁃ ity study was conducted on the reuse of treated wastewater for flotation fluorite from on-site tungsten tailings （CaF₂ content of 20% to 22%）. The results showed that the wastewater with high alkalinity and high COD treated by sodium hypochlorite oxidation，electro-oxidation，activated carbon adsorption and Fenton oxidation process could effectively reduce the COD of wastewater，and electro-oxidation，activated carbon adsorption and Fenton oxidation process could reduce the turbidity of wastewater. Compared with the wastewater directly reused for fluorite flotation，the flotation effects of the treated wastewater from each process were improved，with the best effect of the activated carbon adsorption process. The concentrate index of fluorite flotation was close to the laboratory clear water，with CaF₂ concentrate grade of 95.63% and recovery rate of 43.16%，which means the treated water by the activated carbon adsorption process can be reused in fluorite flotation process.

Key words: dressing wastewater, advanced treatment, wastewater reuse, fluorite flotation

薛珂, 李文风, 周瑜林, 缪亚兵, 陈文胜. 多金属矿尾矿库溢流水深度处理并回用于萤石浮选试验[J]. 现代矿业, 2023, 39(04): 110-.

XUE Ke, LI Wenfeng, ZHOU Yulin, MIAO Yabing, CHEN Wensheng. Test on Advanced Treatment of Overflow Water from Polymetallic Tailing Pond and Its Reuse in Fluorite Flotation[J]. Modern Mining, 2023, 39(04): 110-.

[1]	安昌. 西藏某铅锌矿选矿厂回水处理工艺研究与实践[J]. 现代矿业, 2020, 36(07): 233-235.
[2]	徐少华, 林恬盛, 张军, 刘建国, 张红英, . 超薄稀土磁盘分离机的研制与应用研究[J]. 现代矿业, 2020, 36(02): 84-.
[3]	尚锦燕. 选矿药剂中的环保问题#br#[J]. 现代矿业, 2020, 36(02): 212-.
[4]	董栋, 郭保万, 孙伟. 铅锌选矿废水净化处理试验[J]. 现代矿业, 2013, 29(09): 143-145+152.
[5]	刘维廉, 吕新彪. 钨矿废水循环利用的试验研究[J]. 现代矿业, 2009, 25(12): 45-47.
[6]	高峰, 刘四清, 刘玫华. 甘肃某地铅锌矿浮选废水处理与回用新工艺[J]. 现代矿业, 2009, 25(1): 101-104.
[7]	刘年兰, 黄万抚. 某铅锌选矿厂废水处理工艺探讨 [J]. 现代矿业, 2008, 24(10): 67-69.

扫码分享