欢迎访问《现代矿业》杂志官方网站，今天是 分享到：
×

扫码分享

现代矿业 ›› 2018, Vol. 34 ›› Issue (11): 99-102.

• 矿物加工工程 • 上一篇    下一篇

某低品位伟晶岩型锂辉石选矿试验

刘广学1,2，戴科伟3，常学勇1,2，赵恒勤1,2，翁成钧3   

  1. 1.中国地质科学院郑州矿产综合利用研究所；2.国土资源部多金属矿评价与综合利用重点实验室；3.江西西部资源锂业有限公司
  • 出版日期:2018-11-25 发布日期:2018-12-27
  • 基金资助:

    * 中国地质调查局地质调查项目（编号：121201017000160907）。

Beneficiation Experiment on a Low Grade Pegmatite Type Spodumene Ore

Liu Guangxue1,2，Dai Kewei3，Chang Xueyong1,2，Zhao Hengqin1,2，Weng Chengjun3   

  1. 1.Zhengzhou Institute of Multipurpose Utilization of Mineral Resources,Chinese Academy of Geological Sciences；2.Key Laboratory of Polimetallic Ores Utilization of Ministry of Land and Resources；3.Jiangxi Western Resources Lithium Industries Co.,Ltd.
  • Online:2018-11-25 Published:2018-12-27

摘要： 为降低某低品位伟晶岩型锂辉石选矿生产成本，采用重介质分选工艺，预测可抛弃近70%的粗粒尾矿，可获得Li2O品位为5.25%，Li2O回收率为63.70%的锂辉石精矿。为提高其选矿回收率，采用研发的捕收剂EL进行了浮选试验研究，试验可获得Li2O品位为4.12%，Li2O回收率为80.76%的锂辉石精矿。精选抛尾工艺流程可在一定程度上消除矿泥对精选的影响，同时减少金属量在矿泥中的损失，该研究成果对选矿厂技术改造具有一定的指导意义。

关键词: 伟晶岩, 锂辉石, 重介质分选, 浮选

Abstract: In order to reduce the dressing production cost of a low grade pegmatite type spodumene,it predicted that using heavy medium separation process could discard nearly 70% coarse tailings and obtain spodumene concentrate with Li2O grade of 5.25%,recovery rate of 63.70%.For the sake of increasing the recovery rate of beneficiation,flotation experiment study was conducted by using collector EL,and spodumene concentrate with Li2O grade of 4.12%,recovery rate of 80.76% was obtained.To some extent，concentration discarding tailings process could eliminate the influence of slime on the concentration and reduce the meta loss in ore slime.The research results had certain significance to the technical transformation of the processing plant.

Key words: Pegmatite, Spodumene, Heavy medium separation, Flotation

皖公网安备34050402000109号    皖ICP备05002078号-6
版权所有 © 《现代矿业》编辑部
地址：安徽省马鞍山市经济开发区西塘路666号　邮编：243000
电话：0555-2309819/2309829　 传真：0555-2309848　 Email：xdky@vip.163.com
本系统由北京玛格泰克科技发展有限公司设计开发　技术支持：support@magtech.com.cn