攀西某选铁尾矿选钛试验

现代矿业 ›› 2020, Vol. 36 ›› Issue (03): 127-129.

攀西某选铁尾矿选钛试验

祝勇涛^1,2

1.攀钢集团矿业有限公司设计研究院；2.钒钛资源综合利用国家重点实验室

出版日期:2020-03-25 发布日期:2021-09-13

Experimental on Recovery of Tianium from Iron Tailings in Panxi

Zhu Yongtao^1,2

1.Design Research Institute of Panzhihua Steel Group Mining Company;2.State Key Laboratory of Vanadium Titanium Resources Comprehensive Utilization

Online:2020-03-25 Published:2021-09-13

摘要/Abstract

摘要： 为回收利用攀西某选铁尾矿中的钛铁资源，针对该矿矿石性质进行了两段强磁+浮选和隔渣+两段强磁+浮选两种方案的工艺试验对比研究，两种流程开路浮选试验均可获得TiO2品位大于47%的钛精矿，采用隔渣+两段强磁+浮选流程精矿产率和回收率指标较好。在试验室开路试验的基础上进行浮选闭路连选试验，研究结果表明，在原矿TiO2品位为9.59%的情况下，采用隔渣+两段强磁+浮选流程，最终获得了产率8.54%、TiO2品位46.13%、回收率21.63%的钛精矿。

关键词: 钛铁矿高梯度磁选浮选两段强磁

Abstract: In order to recover ilmenite resources from an iron tailings in Panxi，based on the nature of the ore,the comparison of "two stage magnetic separationfloatation"and "slag separationtwo stage magnetic separationfloatation"is carried out,titanium concentrate with TiO2 grade higher than 47% can be obtained by opencircuit flotation in both processes,using the process of"slag separationtwo stage magnetic separationfloatation",concentrate yield and recovery rate index is better.On the basis of open circuit test in laboratory,closed circuit continuous flotation test is carried out,the results of the study showed,using the process of"slag separationtwo stage magnetic separationfloatation",under the condition of TiO2 grade of 9.59% in raw ore,titanium concentrate with 8.54% yield,46.13% TiO2 grade and 21.63% recovery was obtained.

Key words: Ilmenite, High gradient magnetic separation, Floatation, Two stage magnetic separation

祝勇涛, . 攀西某选铁尾矿选钛试验[J]. 现代矿业, 2020, 36(03): 127-129.

Zhu Yongtao, . Experimental on Recovery of Tianium from Iron Tailings in Panxi[J]. Modern Mining, 2020, 36(03): 127-129.